Loading...

Audi A5 Engine Coolant Overflow Hoses

Audi A5 Engine coolant overflow hoses

Starting at $40.95, AutoBuffy stocks 2 engine coolant overflow hoses from URO for the Audi A5. This hose channels excess coolant from the radiator cap into the overflow reservoir and returns it as the engine cools. When it cracks or collapses, coolant is lost rather than recovered, leading to overheating and potential engine damage.

Signs your Audi A5 needs a new engine coolant overflow hose

  • Coolant puddle or dried residue beneath the front of the vehicle near the radiator or reservoir, indicating an active leak from the hose
  • Reservoir stays empty or low even after topping it off, because coolant vents to the ground instead of being recirculated
  • Temperature gauge climbs higher than normal or fluctuates, caused by the cooling system losing its ability to recover lost coolant
  • Visible cracks, swelling, soft spots, or hardening along the length of the hose when inspected with the engine cold
  • Hissing or steam from the engine bay after shutdown, pointing to coolant escaping through a pinhole or split near a hose clamp
  • Burning or sweet coolant smell inside or outside the cabin, produced when leaking coolant contacts hot engine surfaces

Which engine coolant overflow hose should you buy for your Audi A5?

The main decision is matching the hose material and construction to how your Audi A5 is used and how long you want the repair to last. OE-style molded hoses restore factory fit immediately, while universal hoses require trimming and may need additional fittings. Check whether your A5 uses a single straight hose or a shaped, molded run before ordering.

OE-style molded replacement
Best for
Restoring factory fit with no trimming or adapters
What you get
Pre-shaped EPDM rubber hose that matches the exact routing and clamp positions of the original
Universal straight hose (cut-to-fit)
Best for
Budget repairs or hard-to-find fitments where a molded hose is unavailable
What you get
Flexible straight rubber or silicone hose sold by the foot; requires cutting to length and may need right-angle adapters
Silicone performance hose
Best for
High-heat applications, modified engines, or owners who want a longer-lasting upgrade
What you get
Reinforced silicone construction that resists heat, ozone, and electrochemical degradation better than standard EPDM rubber
OEM-brand replacement
Best for
Owners who want the exact specification used by the manufacturer
What you get
Sourced from or built to the original equipment supplier's spec; typically the highest cost but guaranteed dimensional accuracy

Engine coolant overflow hoses brands we stock for your Audi A5

URO
2 options · from $40.95

Replacing the engine coolant overflow hose on a Audi A5

Easy⏱ 30–60 minutesFlathead or Phillips screwdriver (for spring or worm-gear clamps)Pliers or hose clamp pliersDrain pan or ragsFlashlight or work light

Let the engine cool completely, then loosen the clamps at each end of the old hose and pull it free from the radiator overflow port and reservoir fitting. Slide the clamps onto the new hose, push each end fully onto its fitting, and reposition the clamps past the bead or ridge on each port. Top off the reservoir to the correct level and run the engine to verify there are no drips.

Frequently asked questions

How much does it cost to replace engine coolant overflow hoses on a Audi A5?
The part itself starts at $40.95 for the Audi A5. DIY total cost is usually just the hose plus a clamp or two. Shop labor is minimal — typically under an hour — so professional installation adds a modest labor charge on top of the part price.
Can I drive my Audi A5 with a leaking coolant overflow hose?
You should not drive more than necessary. A leaking overflow hose prevents the cooling system from recovering lost coolant, so the reservoir empties and the engine runs progressively low on coolant. Continued driving risks overheating, which can warp cylinder heads or cause more serious internal engine damage.
How long does an engine coolant overflow hose last on a Audi A5?
Most EPDM rubber overflow hoses last somewhere in the range of several years to over a decade, depending on heat cycling, coolant condition, and climate. Hoses degrade faster when coolant is not changed on schedule, because acidic old coolant attacks rubber from the inside. Inspect the hose whenever you check coolant level.
Is the coolant overflow hose the same as the radiator hose on a Audi A5?
No. Radiator hoses are large-diameter, high-pressure hoses that carry coolant directly between the engine and radiator. The overflow hose is a smaller, low-pressure hose that connects the radiator's overflow fitting to the plastic reservoir. It handles only the coolant that expands out of the system, not the main pressurized coolant flow.
Do I need to drain the cooling system to replace the overflow hose on a Audi A5?
Usually not. Because the overflow hose sits between the radiator neck and the reservoir — outside the pressurized loop — you can typically replace it with only minor coolant spillage. Allow the engine to cool completely first, have rags ready, and check that the coolant level is correct when finished.
What happens if I use the wrong size overflow hose on my Audi A5?
An incorrect inner diameter creates a loose fit at the radiator neck or reservoir port, leading to leaks or the hose blowing off under pressure. A hose that is too long or poorly routed can contact hot surfaces and fail prematurely. Always verify the hose fits your specific A5 before installing.

Shop engine coolant overflow hoses by year for the Audi A5

20142013201220112010

More parts for your Audi A5

Strut MountExhaust Pipe Flange GasketFuel LineWasher Fluid Reservoir CapEngine MountCabin Air Temperature SensorHVAC Blower MotorEngine Crankshaft Position Sensor Connector

Engine coolant overflow hoses for other Audi models

Audi A5 QuattroAudi Q5Audi A4Audi A4 Quattro