Loading...

Chrysler Lebaron Secondary Air Injection Pump Check Valves

Chrysler Lebaron Secondary air injection pump check valves

Starting at $24.95, AutoBuffy stocks 4 secondary air injection pump check valves from Standard Ignition. This one-way valve prevents exhaust backflow from reaching and destroying the air injection pump during cold-start emissions cycles. When it fails, the pump overheats, codes set, and your Chrysler Lebaron will fail emissions inspection.

Signs your Chrysler Lebaron needs a new secondary air injection pump check valve

  • Check engine light with codes P0410, P0411, P0412, or P0418 stored in the ECM
  • Burned or seized secondary air injection pump caused by exhaust gas backflow through the failed valve
  • Rattling or clicking noise from the air injection system during cold start warm-up cycle
  • Failed state emissions or smog inspection due to secondary air system fault
  • Melted or heat-damaged vacuum hose connected to the check valve diaphragm
  • Secondary air system runs but oxygen sensor readings show no corresponding increase in upstream O2 levels

Which secondary air injection pump check valve should you buy for your Chrysler Lebaron?

The most important buying decision is whether to choose an OE-equivalent valve with a steel or reinforced diaphragm housing versus a budget replacement. You should also confirm whether your Chrysler Lebaron uses one valve per bank or a single shared valve, as some applications require two. Material quality matters most here — a cheap diaphragm that cracks again will take the pump with it.

OE-equivalent check valve
Best for
Drivers who want a direct fit and long service life
What you get
Matched housing dimensions, heat-rated diaphragm, and correct flow direction for your Chrysler Lebaron's system
Heavy-duty / upgraded check valve
Best for
High-mileage vehicles or repeat failures on the same engine
What you get
Reinforced metal or composite housing, thicker diaphragm, better heat resistance than stock
Bank 1 or Bank 2 specific valve
Best for
V6/V8 engines with separate air injection lines per cylinder bank
What you get
Correct port orientation and fitting size for the specific side of the engine where the failure occurred
Budget / economy replacement
Best for
Low-mileage vehicles needing a short-term or inspection-passing fix
What you get
Lower upfront cost but may use thinner diaphragm materials with a shorter service life

Secondary air injection pump check valves brands we stock for your Chrysler Lebaron

Standard Ignition
4 options · from $24.95

Replacing the secondary air injection pump check valve on a Chrysler Lebaron

Moderate⏱ 45 minutes – 2 hoursSocket set with extensionsScrewdrivers (flathead and Phillips)Hand vacuum pump (for testing before and after)Hose pick or clip removal toolPenetrating oil for corroded fittings

Access to the check valve on a Chrysler Lebaron depends on its location in the engine bay — some are easily reached near the valve cover, while others are tucked behind the intake manifold and require partial disassembly of surrounding components. Disconnect the air hose and any vacuum line or electrical connector, remove the mounting hardware, and install the new valve with hose clamps snug but not overtightened. Always clear the fault codes and run the engine through a complete cold-start warm-up cycle to confirm the secondary air system passes readiness monitoring before an emissions test.

Frequently asked questions

How much does it cost to replace secondary air injection pump check valves on a Chrysler Lebaron?
Parts start at $24.95 for a check valve on a Chrysler Lebaron. The valve itself is relatively inexpensive, but labor can raise the total cost significantly if the valve is buried under intake components or requires partial disassembly of the air injection plumbing. Replacing the valve proactively when the pump is changed is strongly recommended.
Can a bad check valve destroy the secondary air injection pump on a Chrysler Lebaron?
Yes — this is the most common consequence of a failed check valve. When the diaphragm cracks or the valve sticks open, hot exhaust gas travels backward into the air injection pump during shutdown or deceleration. The heat and combustion byproducts rapidly degrade pump internals, leading to premature pump failure that costs significantly more to repair.
Will a failed secondary air injection pump check valve cause a smog or emissions test failure on a Chrysler Lebaron?
Yes. A failed check valve typically triggers a P0410-series code, which illuminates the check engine light. Any active or pending MIL will cause an immediate emissions inspection failure in most states. Even if the light is cleared, readiness monitors for the secondary air system must complete a full drive cycle before the vehicle will pass.
How do I know if the check valve or the pump itself is the problem on my Chrysler Lebaron?
Apply vacuum directly to the check valve with a hand vacuum pump. A healthy valve should hold vacuum without bleeding down. If it leaks immediately, the valve has failed. You can also disconnect the outlet hose and check for exhaust soot or heat damage inside — contamination confirms backflow occurred and the valve diaphragm is compromised.
Should I replace the check valve and the pump at the same time on a Chrysler Lebaron?
If the pump has already been exposed to exhaust backflow — evidenced by soot inside the hoses or a burned pump smell — replacing both at the same time is the practical choice. Installing a new check valve on a pump with heat-damaged internals usually results in a second pump failure within a short period, doubling the total repair cost.
How long does a secondary air injection pump check valve last on a Chrysler Lebaron?
Service life varies widely depending on climate, driving habits, and material quality. In general, OE-quality valves last many years under normal use. Vehicles in cold climates that rely heavily on the cold-start air injection cycle tend to wear valves faster. Cheap replacement valves with thin rubber diaphragms can fail within a relatively short time after installation.

Shop secondary air injection pump check valves by year for the Chrysler Lebaron

199419931992199119901989198819871986198519841983198219811980197919781977

More parts for your Chrysler Lebaron

A/C Compressor Clutch BearingFuel Injector Seal KitA/C Manifold Hose AssemblyIgnition Coil Mounting BracketAutomatic Transmission Oil Cooler HoseEngine Air FilterOxygen Sensor ConnectorA/C Suction Line Hose

Secondary air injection pump check valves for other Chrysler models

Chrysler DaytonaChrysler CordobaChrysler LaserChrysler ConquestChrysler New YorkerChrysler Imperial