Loading...

Chrysler Tc Maserati Headlight Switch Connectors

Chrysler Tc Maserati Headlight switch connectors

Starting at $59.95, AutoBuffy stocks 2 headlight switch connectors from Standard Ignition that fit the Chrysler Tc Maserati. This connector is the wiring harness plug that delivers power and ground signals between the vehicle's wiring loom and the headlight switch itself. When it fails — due to heat damage, corrosion, or melted terminals — the headlights may flicker, stay off entirely, or become uncontrollable, creating a serious safety hazard.

Signs your Chrysler Tc Maserati needs a new headlight switch connector

  • Headlights flicker intermittently, especially over bumps or during temperature changes, indicating a loose or corroded terminal inside the connector
  • Headlights fail to turn on at all even though the switch, fuses, and bulbs test good — pointing to a broken pin or melted connector body
  • Headlights stay on and cannot be switched off, caused by a shorted or fused terminal holding the circuit closed
  • Visible burn marks, melted plastic, or a burning-plastic smell near the headlight switch area on the dash
  • Interior dash lighting controlled by the same switch (panel dimmer, parking lights) cuts out or behaves erratically alongside the headlights
  • Diagnostic trouble codes or body control module faults related to the exterior lighting circuit with no other obvious wiring damage

Which headlight switch connector should you buy for your Chrysler Tc Maserati?

The main decision is whether to match the original connector's terminal count and locking tab design exactly, and whether to choose a bare pigtail connector or a pre-terminated repair harness. OEM-style connectors restore factory fit and weatherproofing, while universal repair pigtails require soldering but work across a wider range of vehicles. Always confirm the number of pins and the connector body style against your existing plug before ordering.

OEM-match pigtail connector
Best for
Clean, like-factory repair with no modifications
What you get
Exact pin count, factory locking tab, correct wire gauge, and matching connector body color
Standard repair pigtail (bare leads)
Best for
DIYers comfortable with soldering or crimp splicing
What you get
Pre-populated terminals in the correct connector shell; you splice onto existing wiring
Pre-wired weatherproof connector
Best for
Vehicles in high-moisture or off-road environments
What you get
Sealed connector body with silicone-gasketed terminals for superior corrosion resistance
Universal multi-pin repair kit
Best for
Shops that need to cover multiple vehicle applications
What you get
Loose terminals, connector shells, and seals sold together; requires terminal extraction tool and manual pin insertion

Headlight switch connectors brands we stock for your Chrysler Tc Maserati

Standard Ignition
2 options · from $59.95

Replacing a headlight switch connector on a Chrysler Tc Maserati

Easy⏱ 30–60 minutesTerminal pick or terminal removal toolSoldering iron and rosin-core solder (or ratcheting crimp tool)Heat-shrink tubing and heat gunWire strippersMultimeter for circuit verification

Start by disconnecting the negative battery terminal to eliminate any risk of shorting the lighting circuit while you work. Remove the old connector by depressing its locking tab and unplugging it, then use a terminal pick to release and transfer any salvageable wires, or cut the harness back to clean wire and splice the new pigtail using soldered, heat-shrunk joints for a reliable connection. Reconnect the battery, test all headlight functions through their full switch range, and confirm no warning lights remain before returning the vehicle to service.

Frequently asked questions

How much does it cost to replace headlight switch connectors on a Chrysler Tc Maserati?
The part itself starts at $59.95 for the Chrysler Tc Maserati. DIY total cost is typically just the connector plus basic tools if you already own a soldering iron or crimp tool. A shop will add one to two hours of labor, so expect the full repair to run noticeably higher than the part cost alone.
Can I drive my Chrysler Tc Maserati with a faulty headlight switch connector?
You should not drive with a known bad headlight switch connector. If the headlights are inoperative or unreliable, the vehicle is unsafe to operate after dark and may be illegal to drive in most jurisdictions. A melted or shorted connector also poses a fire risk and should be addressed immediately.
What causes a headlight switch connector to fail on a Chrysler Tc Maserati?
The most common causes are heat cycling that hardens and cracks the plastic connector body, corrosion from moisture intrusion into the terminals, and resistive heating from a loose terminal that eventually melts the connector. Rodent damage to nearby wiring can also stress the connector and cause failure.
Do I need to replace the entire headlight switch if the connector is bad on a Chrysler Tc Maserati?
Not necessarily. If the switch itself tests correctly and only the connector plug is burned or broken, replacing the connector pigtail alone is sufficient and far less expensive. Inspect both components — if the switch pins are also damaged or corroded, replacing both at the same time makes sense to avoid a repeat repair.
Is replacing a headlight switch connector on a Chrysler Tc Maserati a DIY job?
Yes, for most owners comfortable with basic electrical work. The repair involves disconnecting the battery, removing the old connector, splicing or soldering the new pigtail onto the existing harness, and applying heat-shrink tubing to seal the joints. The job generally takes under an hour and requires no special dealer equipment.
How do I know which headlight switch connector fits my Chrysler Tc Maserati?
Match by the number of terminal pins in your existing connector, the connector body locking tab style, and the wire gauge of the leads. The Chrysler Tc Maserati year range is 1989–1991, and connector designs can vary by trim level or market, so confirming with your VIN or the original part number from the old connector ensures an exact fit.

Shop headlight switch connectors by year for the Chrysler Tc Maserati

199119901989

More parts for your Chrysler Tc Maserati

HVAC Harness ConnectorHVAC Heater RelayOxygen Sensor ConnectorCoil Spring SeatA/C Clutch RelayEngine Balance Shaft Chain TensionerPCV ValveRack & Pinion Bellows Kit

Headlight switch connectors for other Chrysler models

Chrysler Fifth AvenueChrysler E ClassChrysler DaytonaChrysler New YorkerChrysler Executive LimousineChrysler Newport