Loading...

Gmc P15/P1500 Van A/C Compressor Throttle Cut-Off Relays

Gmc P15/P1500 Van A/c compressor throttle cut-off relays

Starting at low prices, AutoBuffy stocks multiple A/C compressor throttle cut-off relays from top OE-quality brands. This relay signals the engine control system to briefly reduce throttle output the moment the A/C compressor clutch engages, preventing the rough surge or stumble that would otherwise occur. When it fails, drivability and A/C reliability both suffer.

Signs your Gmc P15/P1500 Van needs a new A/C compressor throttle cut-off relay

  • Engine stumbles, lurches, or briefly loses power every time the A/C compressor kicks on
  • Noticeable RPM drop or near-stall at idle when the air conditioning is switched on
  • A/C clutch engages erratically or cycles on and off more frequently than normal
  • Check Engine light appears with codes related to idle control, throttle position, or the A/C clutch circuit
  • Rough idle that smooths out immediately after turning the A/C off
  • A/C system blows warm air intermittently because the compressor fails to stay engaged consistently

Which A/C compressor throttle cut-off relay should you buy for your Gmc P15/P1500 Van?

The main decision is whether to match the OE relay specification exactly or upgrade to a heavy-duty unit rated for higher current loads. You should also confirm the relay's pin configuration and mounting style, as a mismatch in footprint will prevent a secure fit even if the voltage rating is correct.

OE-Equivalent Relay
Best for
Owners wanting a direct, plug-and-play replacement with factory-spec performance
What you get
Same resistance, pin layout, and current rating as the original; confirmed fitment for your Gmc P15/P1500 Van
Heavy-Duty Relay
Best for
Vehicles with high-draw A/C systems or those that have experienced repeated relay failures
What you get
Higher contact current rating and reinforced coil for longer service life under heat and vibration
Multi-Pack / Value Set
Best for
Fleets, high-mileage vehicles, or owners who want a spare on hand
What you get
Two or more relays at a lower per-unit cost; ideal when the relay is a known weak point on your P15/P1500 Van
Integrated Relay Module
Best for
Vehicles where the throttle cut-off function is combined with other A/C control logic in one unit
What you get
Replaces a broader section of the A/C control circuit, reducing the chance of related component failure

Replacing the A/C compressor throttle cut-off relay on a Gmc P15/P1500 Van

Easy⏱ 15–30 minutesRelay puller or flat-blade screwdriverMultimeterNeedle-nose pliersElectrical contact cleanerGloves and eye protection

Locate the relay in the underhood fuse and relay box using the diagram printed on the box cover or in your owner's manual, then pull the old relay straight out — a relay puller or the tip of a flat-blade screwdriver prevents pin damage. Before seating the new relay, spray the socket terminals with electrical contact cleaner and inspect for corrosion that could cause the new part to fail early. Press the replacement relay firmly into the socket until it seats flush, restore power, and confirm normal idle behavior with the A/C switched on.

Frequently asked questions

How much does it cost to replace A/C compressor throttle cut-off relays on a Gmc P15/P1500 Van?
The part itself starts at low prices at AutoBuffy. Because the relay typically seats in the underhood fuse/relay box, most owners replace it in under 30 minutes with no special tools, keeping total cost close to the part price alone. Shop labor, if needed, is usually less than one hour.
What does the A/C compressor throttle cut-off relay actually do on a Gmc P15/P1500 Van?
When the A/C compressor clutch engages, it places a sudden mechanical load on the engine. The throttle cut-off relay sends a signal to the ECU or throttle body to momentarily increase idle speed or reduce throttle sensitivity, compensating for that load and preventing the stumble or stall you would otherwise feel.
Can I drive my Gmc P15/P1500 Van with a bad A/C compressor throttle cut-off relay?
Yes, but you should avoid running the A/C until the relay is replaced. A failed relay can cause repeated near-stalls in stop-and-go traffic, which is a safety concern. It also places extra stress on the idle air control system and can eventually trigger fault codes that affect other engine management functions.
How do I test the A/C compressor throttle cut-off relay on my Gmc P15/P1500 Van?
Remove the relay from the fuse box and use a multimeter to check coil resistance across the control terminals — it should show continuity within the manufacturer's specified range. You can also apply 12V directly to the coil terminals and listen for a clear click, confirming the internal contacts are closing properly. No click or infinite resistance means the relay has failed.
Is the A/C compressor throttle cut-off relay the same as the A/C compressor clutch relay on a Gmc P15/P1500 Van?
No, they are separate components with different functions. The compressor clutch relay directly switches power to the compressor clutch coil to engage the compressor. The throttle cut-off relay manages the engine's response to that engagement event. Both should be inspected together, but they are not interchangeable and typically do not share the same connector.
How long should an A/C compressor throttle cut-off relay last on a Gmc P15/P1500 Van?
Most relays are rated for tens of thousands of switching cycles and commonly last the life of the vehicle. Premature failure is usually caused by heat soak in the engine bay, corrosion on the relay socket terminals, or voltage spikes from a weak battery or failing alternator. Inspecting the socket for corrosion at replacement time can prevent a repeat failure.

More parts for your Gmc P15/P1500 Van

Tie Rod Adjusting Sleeve KitEngine Water PumpHVAC RelaySpark Plug Wire SetExhaust ClampDrum Brake Wheel CylinderOil Pressure Switch ConnectorA/C Expansion Valve

A/c compressor throttle cut-off relays for other Gmc models

Gmc S15 JimmyGmc P35/P3500 VanGmc C25/C2500 PickupGmc G15/G1500 VanGmc JimmyGmc K15/K1500 Pickup