Loading...

Volvo Xc70 Vapor Canister Purge Solenoids

Volvo Xc70 Vapor canister purge solenoids

Starting at $17.95, AutoBuffy stocks 2 vapor canister purge solenoids from GPD and Standard Ignition for the Volvo Xc70. This solenoid controls when fuel vapors stored in the charcoal canister are drawn into the engine to burn. When it fails, raw fuel vapors vent to the atmosphere, triggering a check engine light and failed emissions tests.

Signs your Volvo Xc70 needs a new vapor canister purge solenoid

  • Check engine light with EVAP-related codes such as P0441, P0444, or P0445 stored in the ECM
  • Rough idle or stalling shortly after a cold start, caused by excess fuel vapor flooding the intake
  • Hard starting or a brief hesitation when the engine is first cranked
  • Noticeable fuel smell inside or around the Volvo Xc70, especially after refueling
  • Failing a state emissions inspection due to an incomplete or failing EVAP monitor
  • Reduced fuel economy as unburned fuel vapors escape rather than being recirculated into combustion

Which vapor canister purge solenoid should you buy for your Volvo Xc70?

The main decision is whether to buy an OE-equivalent unit or a premium solenoid with upgraded internals. Fit and electrical connector style matter most — using the wrong connector type means splicing wires, which can introduce future faults. Always confirm the solenoid matches your Volvo Xc70's engine and model year range.

OE Replacement
Best for
Owners wanting a like-for-like fix at the lowest cost
What you get
Matches factory connector, flow rate, and duty-cycle calibration; clears codes without recalibration
Premium / High-Cycle
Best for
Higher-mileage Volvo Xc70s or harsh climates with wide temperature swings
What you get
Reinforced valve seat and corrosion-resistant housing rated for more open/close cycles before wear
OEM-Supplied (Dealership-Grade)
Best for
Owners under powertrain warranty or who want exact factory part numbers
What you get
Sourced from the original equipment supplier; highest confidence in fit but typically the highest price
Economy / Value Brand
Best for
Budget-conscious repairs or a second vehicle with low remaining service life
What you get
Lower upfront cost; functional replacement but may use thinner plastics and shorter warranty coverage

Vapor canister purge solenoids brands we stock for your Volvo Xc70

GPD
1 option · from $17.95
Standard Ignition
1 option · from $53.95

Replacing a vapor canister purge solenoid on a Volvo Xc70

Easy⏱ 30–60 minutesFlathead and Phillips screwdriversSocket set with extensionsOBD-II scan tool (to read and clear codes)Needle-nose pliers (for hose clamps)

The purge solenoid on most Volvo Xc70s is accessible from the top of the engine bay and secured by one or two bolts plus two vacuum hoses and an electrical connector. Disconnect the battery before unplugging the connector, swap the solenoid, reconnect hoses and wiring, then clear stored codes with a scan tool. After the repair, complete a full drive cycle to confirm the EVAP monitor runs clean before an emissions test.

Frequently asked questions

How much does it cost to replace vapor canister purge solenoids on a Volvo Xc70?
The part itself starts at $17.95 for the Volvo Xc70. DIY replacement keeps total cost near that figure since the job usually takes under an hour. Shop labor typically adds $50–$120 depending on access difficulty. Paying for a shop to diagnose and clear codes can add another $80–$150 if not included.
Can I drive my Volvo Xc70 with a bad vapor canister purge solenoid?
You can drive short distances, but it is not advisable. A stuck-open solenoid floods the intake with raw fuel vapor, causing rough running and potential catalytic converter damage over time. A stuck-closed solenoid traps pressure in the fuel tank. Either failure will keep the check engine light on and will fail an emissions test.
Will replacing the purge solenoid clear the check engine light on my Volvo Xc70?
Replacing a confirmed faulty solenoid resolves the root cause, but the light must be cleared with a scan tool or by disconnecting the battery briefly. The EVAP monitor then needs one or more complete drive cycles to run and confirm the repair. Most auto parts stores will clear codes for free after the fix.
How do I know if the purge solenoid is stuck open or stuck closed on my Volvo Xc70?
A stuck-open solenoid typically causes a rich condition, rough idle right after startup, and codes like P0441 or P0455. A stuck-closed solenoid prevents vapor flow entirely, setting codes like P0444 or P0445 and causing a failed EVAP monitor. A mechanic can confirm which failure mode exists by applying voltage directly to the solenoid and checking for audible click and airflow.
How long does a vapor canister purge solenoid last on a Volvo Xc70?
Most purge solenoids last somewhere between 80,000 and 150,000 miles under normal conditions. Heat cycling near the engine, fuel quality, and exposure to moisture all accelerate wear. The solenoid opens and closes thousands of times per drive cycle, so the valve seat and coil winding eventually fatigue regardless of brand.
Is the vapor canister purge solenoid the same as the vent solenoid on my Volvo Xc70?
No. The purge solenoid sits between the charcoal canister and the intake manifold, pulling vapors into the engine during operation. The vent solenoid sits on the canister's fresh-air side and seals the system during EVAP leak tests. Both are part of the EVAP system but perform opposite functions and are replaced separately.

Shop vapor canister purge solenoids by year for the Volvo Xc70

201420132012201120102009200820072006200520042003

More parts for your Volvo Xc70

Engine Timing Belt TensionerA/C Evaporator CoreBrake CaliperEngine Oil Pump GasketFuel Injector Seal KitAccessory Drive Belt PulleyA/C Suction Line HoseCoil Spring

Vapor canister purge solenoids for other Volvo models

Volvo V90Volvo S60Volvo S90Volvo V60Volvo XC60Volvo C30